보고서 정보
주관연구기관 |
에코필 |
연구책임자 |
정홍배
|
참여연구자 |
김수미
,
김용현
,
김준우
,
김지은
,
심두섭
,
심명호
,
엄찬호
,
이송이
,
이아람
,
송영호
,
고성환
,
박재현
,
김정수
|
보고서유형 | 최종보고서 |
발행국가 | 대한민국 |
언어 |
한국어
|
발행년월 | 2017-06 |
과제시작연도 |
2015 |
주관부처 |
환경부 Ministry of Environment |
등록번호 |
TRKO201800036849 |
과제고유번호 |
1485012878 |
사업명 |
토양지하수오염방지기술개발 |
DB 구축일자 |
2018-08-11
|
키워드 |
유류오염 토양 정화.폐산슬러지.원유오염토양.인도네시아 토양오염복원.Oil contaminated soil Remediation.Acid sludge.Crude oil contaminated soil.Indonesia soil remediation.
|
DOI |
https://doi.org/10.23000/TRKO201800036849 |
초록
▼
개발 목적 및 필요성
인도네시아는 다른 동남아 국가와는 달리 원유를 생산하는 산유국으로 1960년대부터 미국을 비롯한 유럽 국가들이 진출하여 원유 정제산업시설이 활발히 운영중 임. 이들 석유화학 산업시설은 과거 수십 년 동안 유류 산업폐기물을 투기하여 이로 인한 환경오염이 심각한 실정이다. 특히, 1990년 이후 인도네시아 환경부는 과거 유류산업폐기물 투기지역의 토양·지하수 오염을 처리하기 위한 활발한 노력을 이어오고 있음.
기술개발 현장 부지는 인도네시아의 석유산업 도시인 발릭파판(Balikpapan)에 위치하며 50여
개발 목적 및 필요성
인도네시아는 다른 동남아 국가와는 달리 원유를 생산하는 산유국으로 1960년대부터 미국을 비롯한 유럽 국가들이 진출하여 원유 정제산업시설이 활발히 운영중 임. 이들 석유화학 산업시설은 과거 수십 년 동안 유류 산업폐기물을 투기하여 이로 인한 환경오염이 심각한 실정이다. 특히, 1990년 이후 인도네시아 환경부는 과거 유류산업폐기물 투기지역의 토양·지하수 오염을 처리하기 위한 활발한 노력을 이어오고 있음.
기술개발 현장 부지는 인도네시아의 석유산업 도시인 발릭파판(Balikpapan)에 위치하며 50여 년 동안 원유 정제산업에서 발생한 각종 폐기물이 매립되어 있던 부지로 토양 및 지하수 오염은 물론 매립되어 있던 폐산 슬러지(acid sludge)의 수평 유동으로 인해 인근 정유 플랜트에 심각한 영향을 주고 있는 실정임. 이에 인도네시아 환경부는 1990년부터 해당 부지에 대한 오염조사 및 고형화·안정화, 생물학적 처리 등 각종 파일럿 테스트(pilot test)를 시도해왔으나, 큰 성과가 없어, 매립 폐기물을 굴착하고, 오염된 토양 및 지하수를 처리하는 보다 적극적인 정화기술의 도입을 희망하고 있음.
연구개발 결과
가. 최적공법 선정을 위한 부지특성 및 오염 현황 평가
- 유사 원유 정제 폐기물 매립지역 복원 사례 문헌 조사
인도네시아 토양복원 관련사례는 많지 않으며, 2003년 제정된“유류로 오염된 토양의 생물학적 처리 기술의 절차 및 관련 시설 규정”이후 시행된 생물학적 정화사례가 유일하며, 산성 슬러지(acid sludge) 폐기물 매립부지 복원 사례로 슬로베니아(Slovenia)에 위치한 정유 폐기물을 처분한 오일 라군(Oil lagoon) 처리 사례가 있음.
- 기존의 부지 오염 현황조사 자료 수집 및 분석
- 전체 오염 부지 중 본 과제 수행을 위한 현장 실증 부지 면적에 대한 오염분포 현황 상세조사
산성 슬러지(acid sludge)의 매립심도는 지하 2~5m 사이에 집중적으로 분포하고 있다. 발주처인 Pertamina의 기존 조사 자료에 의하면, 매립 면적은 약 7,953㎥ 이며, acid sludge 및 오염토양의 부피는 22,561㎥ 임.
- 시료채취 및 오염도 분석
산성 슬러지(acid sludge) 덩어리 자체의 중금속 함량과 TPH 오염농도를 분석한 결과는 표 1-3에 나타 내었으며, 구획(Plot)별 TPH 토양오염농도를 분석한 결과 0.2~9.7%의 범위를 보였음.
- 인도네시아 환경부가 제시하는 환경복원 기준 및 표준 분석법 자료 조사
인도네시아 환경법 (Permen LH no. 33/2009)에 의하면, 오염부지 정화목표 수준은 다음과 같은 3가지 방법으로 정할 수 있음. 1) 배경토양 농도에 의한 정화목표 설정, 2)부지 사용용도에 따라 표준 정화목표 설정, 3) 위해성평가를 바탕으로 한 정화목표 설정. 해당 부지에 대해서는 주변 배경농도를 활용하여 정화목표를 설정하였으며, 인도네시아 환경부과 부지정화의 주체인 Pertamina가 최종 합의하여 도출한 정화목표는 TPH 4,300mg/kg 임.
- 해당지역의 오염물질 분포 특성 및 오염물질의 거동 분석
매립되어 있는 산성 슬러지(acid sludge)는 지중에서의 물리 화학적 작용에 의해 지표의 틈을 따라 유독가스와 함께 분출하여, 부지 곳곳에 검은 용암의 형태로 분출되어 굳어져 있었으며, 과거만큼 활발하지 않지만, 여전히 검은 산성 슬러지(acid sludge)의 분출이 지금도 간간히 발생되고 있는 실정임.
나. 현장맞춤형 정화를 위한 정화공법의 적용성 연구
- 대상 부지의 토양 특성 및 중금속 등의 배경농도 확인
- 토양오염도 분석
인도네시아 표준 분석법에 의한 TPH 농도는 토양이 3.2~4.2%, acid sludge는 6.8~7.4%로 분석되었음. 중금속의 경우 기준치를 초과한 항목은 없었으며, 인도네시아 분석법으로 아연을 제외하고는 모든 중금속은 검출한계 미만으로 나타남.
- 토양 및 매립 폐기물을 선별 전처리 실험
습식 입도분석 결과, 미세토 함량은 약 18.8% 였으며, 토성은 세립질 모래로 분류되었음. 입도별 입자를 관찰한 결과 고형의 산성 슬러지(acid sludge)가 다양한 크기로 모든 구간에 혼합분포하고 있음.
- 폐산성 슬러지(acid sludge)의 성상 분석
산성 슬러지(acid sludge 자체의 열량은 약 5,000Kcal/kg으로 저 품위 석탄 정도의 열량을 나타내었으며, 점토성분의 sludge의 영향으로 불연분이 약 11% 함유되어 있었다.
원소분석 결과 탄소 함량이 57.8~63.03%, 황 함량은 4% 미만으로 나타남.
- 적용 가능 공법의 타당성 시험
토양 및 오염물질의 특성을 분석한 결과 해당 부지의 오염물질인 산성 슬러지(acid sludge)는 wax 생산 공정에서 발생된 폐기물로서, 주로 고형의 석유계 오염물질인 것으로 판단되어, 생물학적 이용도가 떨어지며, 부지전체의 오염토량이 많고, 짧은 기간내에 정화를 해야 하는 여건에 맞추어 오염토양을 굴착하여 처리하는 Ex-situ 공법에 대해서만 공법 적용성 검토대상으로 하였으며, 생물학적 정화방법을 포함한 토양세척법과 열탈착 공법에 대해서 적용성 시험을 수행하였음. 본 연구를 통해 다양한 TPH제거 공법들을 적용해 보았지만 단 시간에 가장 효과적으로 TPH를 제거하는 방법으로는 열탈착 공법이 가장 효과적인 공법으로 나타남.
- 현장 실증 플랜트 설계 인자 도출 실험
대상 시료에 대한 열탈착 실험은 TGA-DSC의 결과에 따라 회화로를 이용하여 진행하였음. 약 350℃~400℃의 조건으로 열탈착 공정을 운영하면 인도네시아 환경기준을 만족할 수 있을 것으로 판단되었음.
다. 최적 정화공법선정 및 실증플랜트 설계(0.5ton/hr)
- 적용성 시험 결과 분석
- 선정공법의 현장 적용성 및 경제성 검토
- 정화 플랜트 제작 및 현지 설치에 대한 효율성 분석
- 정화공법 적용에 따른 각종 인허가 및 규제사항 검토
- 정화공정 폐기물의 처리 방안 검토 및 인근 폐기물 처리시설 검토
인도네시아에서 폐기물 처분 허가를 보유한 유일한 업체는 PT. Prasadha Pamunah LimbahIndustri(PPLi) 임. 1994년부터 유해/비유해 폐기물의 수집, 처리, 처분 및 재활용 서비스를 제공하는 인도네시아 업체로 95%의 지분을 Modern Asia Environmental Holdings (MAEH) 가 소유하고 정부가 나머지 5%의 지분을 소유하고 있음.
- 경제적 효율적 합리적 최적 정화공법의 선정
최적 정화공법 선정절차 제시.
- 현장실증 플랜트의 상세 설계
직접 가열 방식의 열탈착 공정은 토양정화 공정과 대기오염물질 처리 공정으로 구분됨. 열탈착 정화는 선별공정에서 20mm 이하로 분리된 오염토양이 호퍼에 투입되며,열탈착 킬른에서 약 20~30분의 체류시간을 거쳐 정화토양으로 배출하게 됨. 킬른에서 발생된 유증기 ․ 수증기 ․ 미세먼지는 음압에 따라 후단 대기오염물질 처리 시설로 이동하여 처리됨.
라. Pilot 규모 현장실증 플랜트(0.5ton/hr) 제작 및 설치 운전
- Pilot 플랜트 제작 및 해외 실증 부지 이송방안 검토
대외무역법 제11조 및 동법 시행령 제19에 관한 대외무역관리규정 제 19조에 따라 해외 건설업(투자, 건설, 용역, 산업설비수출)에 종사하는 우리나라 건설업자(현지 합작법인을 포함)는 해외건설공사에 필요한 물품을 무환으로 송출하는 경우 국토교통부장관이 지정한 확인기관인 해외건설협회로부터 반드시 확인 필요
- 플랜트 해외 이송에 따른 각종 양국의 인허가 사항 및 세제 검토
- 플랜트 현장 설치 및 현장 운영에 관한 해당국의 각종 인허가 및 규제사항 검토
해당 주 정부의 승인 및 환경부의 승인이 있어야 플랜트의 설치가 가능.
마. 실증플랜트 성능 및 정화효율 평가
- 현장 실증 플랜트의 규격평가=> 0.5ton/hr, 4hr/day 이상
시간당 0.5톤 이상 용량의 실증평가 장치 사용 함.
- 실증 플랜트의 각 세부 장치별 성능 평가
- 전체 연동 테스트
실증 플랜트 각 세부 장치별로 설명하였으며, 전체 연동 테스트를 수행하였음.
- 정화 효율 평가 => 초기 오염농도 대비 80% 이상의 정화 효율 및 최종 정화목표
농도 TPH 1,000 mg/kg 이하 달성 여부 확인
처리온도 400도, 체류시간 20분 조건에서 초기 원 오염토양 유류농도 54,800mg/kg에서 처리 후 채취한 토양에서 유류성분 농도가 검출한계 이하로 분석 됨.
바 현지 토양특성 . , 오염특성 및 제도(환경기준 등)를 고려한 최적공정개발 및 경제성분석
- 해안가 인근에 위치하한 현장 실증부지의 지리적 위치 및 열대성 기후특성을 고려한 최적의 정화공정 선정
현 오염부지는 굴착이 가능한 부지로 생물학적, 물리적 세척, 열탈착 시험을 시행하여 평가한 결과 열탈착 공법이 가장 타당한 공법으로 판단되었음.
- 정화공정 운영시 발생되는 각종 폐수, 배가스, 관한 규제항목 및 배출기준 검토
대기오염방지에 관한 규제기준은 법령 Decree of the State Minister of Environment No.2 of 1988을 통해 단일화된 전체 대기환경기준이 처음 마련됐음. 배출물질기준과 관련해 고정오염원에 대한 5개 종류의 기준이 환경부장관령 Decree of the State Minister of Environment No. 13 of 1995을 통해 마련되었음. 자동차로 인한 유해가스와 관련해 환경부장관령 Decree of the State Minister of Environment No. 35 of 1993을 통해 유해가스와 차량의 공회전시의 측정치에 대한 규제에 대해 설명하고 있음.
- 인접지역의 폐기물 처리시설 위치확인 및 처리비용 비교 검토
인도네시아에서 폐기물 처분 허가를 보유한 유일한 업체는 PT. Prasadha Pamunah LimbahIndustri(PPLi) 임. MAEH는 2009년 일본 Dowa Holdings Co., Ltd. 의 자회사인 Dowa Eco System Co. Ud 에 인수된 회사로 고체/액체 폐기물 처리, 폐기물 처리, 연료 재활용, 토양 정화를 실시하며 매립 시설, 폐유, 유체처리시설을 보유하고 있음. 처리비용은 지정폐기물 처리 톤당 200$ 임.
- 인도네시아 환경부(KLH)가 제시하는 최종 정화목표 확인
KLH와 PERTAMINA가 협의하여 정화기준으로 확정함. 정화기준은 관련법 Annex 4에 따라 환경부와 발주처가 토양 참고치 위치를 지정하고 최소 시료 수 이상의 참고치를 분석하여 기를 부지복원의 기준치로 협의 함(TPH 4,300mg/kg)
- 현장실증 운영비용 분석을 통해 정화공정의 경제석 분석
정화 내역서는 아래와 같으며, 오염토양 톤당 정화단가는 188,600원/톤(157$/ton,2016년 말 환율 기준)로 산출되어 비교대상이었던 매립지에 처분하는 단가 200$/ton 이하로 나타남.
사. 현지운영을 위한 가이드라인 작성
- 현지에서 정화공사 사업을 위해 필요한 인허가 사항 및 자격조건 확인
인니 환경부 규정 33/2009에 의해 신고 되고 승인되어야 하며, 특히 생물학적 처리의 경우 환경부 규정 128/2003 에 의해 기술적 요구사항을 정의하고 있음.
- 인도네시아 토양오염 복원사업의 현황 및 시장성 조사
2005년부터 2008년, 2010년부터 2012년 사이에 총 12개 주에서 용적 2,680,601m3,면적 6,930,473m2인 총 67개의 오염부지가 발견되었음. 리아우주에서 용적2,680,601m3, 면적 6,930,473m2의 대규모 오염부지가 발견되었으며 이는 오일 및 가스 산업활동에 기인한 것으로 파악됨. 현재 인도네시아에서 공식적으로 발표된 토양·지하수 오염 규모에 대한 정보는 없으며, 오염 현황 및 주로 적용되는 정화 기술에 근거하여 추정 시 최소 약 2천 8백억 원에서 최대 9천억 원 규모의 시장이 형성되어 있는 것으로 예측됨.
- 정화사업 진행에 관련된 법규 및 각종 인허가 사항 및 규제항목 정리
- 유류오염토양 (특히 원유 정제 폐기물 매립에 의한 유류오염토양)의 정화를 위한 합리적 공법 선정 절차 정립
오염토양 정화공법 선정절차 제시
- 선정된 공법의 현지 적용을 위한 고려사항 정리
현지 적용을 위하여 해당국 인허가, 배출기준, 폐기물 처리방안, 해외이송 적합성 및 기후를 고려하여 대응하여야 함.
- 오염토양의 굴착 및 정화플랜트 설치 운영에 따른 인허가 및 규제사항 정리
- 정화공정 운영시 고려해야할 안전관리 항목 정리
열탈착 공정의 경우 특히 화재, 폭발, 작업 중 소음, 작업 중 화상, 작업 중 감전, 작업장 분진에 주의해야 함.
- 정화공정 폐기물의 발생 및 처리과 관련된 사항 정리
열탈착 정화공정에서 발생할 수 있는 폐기물은 오염된 토양이 로터리 킬른에서 열탈착 과정을 거치는 과정에서 발생한 분진임. 발생한 분진 중 입도가 큰 분진들은 멀티사이클론의 원심력에 의해서 분리 후 집진과정을 거치며 남은 분진들은 공정 중 백필터를 통해 필터 천에 분진을 함유한 기류를 통과시키고 이 여과 천에 분진을 포착하는 원리로 집진됨. 열탈착 공정에서 발생한 분진의 처리는 분진의 농도가 토양오염 우려기준의 기준치 이하일 경우 정화토와 섞어서 배출하며 분진의 농도가 토양오염 우려기준의 기준치 이상일 경우 분진은 지정폐기물로 처리.
- 최종 가이드라인 작성
설계 가이드라인 및 표준운전절차서 작성
성능사양 및 기술개발 수준
본 연구개발을 통하여 고농도 유류오염토양 정화를 위한 시간당 7톤 용량의 설비를 설계하고 제작하는 기술을 보유하게 되었음.
고농도 유류 오염토양의 정화에 대해서는 현재 기술적 가이드라인이 전무한 상황임. 본 연구개발로 고농도 유류 오염정화관련 열탈착 정화 가이드라인을 제공하고 표준작업절차서를 제공하여 열탈착 정화기술의 적용성을 더욱 높일 것으로 판단됨. 해외의 경우 미국에서 가장 정화활용 사례가 많으며, 연구개발이 완료된 현재 기술수준은 미국의 90% 수준까지 올라옴.
활용계획
해외 토양정화시장의 경우 대부분 산유국 중심으로 구성되어 있으며 고농도의 유류(원유)오염으로 이루어져 있다. 이 처리를 위해서는 열탈착 기술이 필수적이다. 개발된 기술로 동남아시아, 중동, 중국의 오일 & 가스 발주처 고농도 유류오염토양 정화사업에 활용할 것임.
또한 해외 원유탱크 슬러지 정화, 농약오염토양 정화에도 활용할 계획이며,국내의 경우 고농도 유류오염토양 정화를 위한 열탈착 공정지정 사업에도 활용할 계획임.
( 출처: 요약서 5p )
Abstract
▼
Ⅳ. Results
A. Evaluation of properties of premises for site selection and optimal contamination
- Similar Crude Oil Refuse Waste Reclaimed Area Recovery Case Literature Survey
There are not many cases related to soil restoration in Indonesia, and cases of biological purification that took e
Ⅳ. Results
A. Evaluation of properties of premises for site selection and optimal contamination
- Similar Crude Oil Refuse Waste Reclaimed Area Recovery Case Literature Survey
There are not many cases related to soil restoration in Indonesia, and cases of biological purification that took effect since the 2003 "Procedure of Biological Treatment Techniques for Soils Contaminated with Soil and Related Facilities" There is an example of oil lagoon processing where the essential oil waste disposed in Slovenia was disposed of in the case of restoration of the landfill section of acid sludge waste
- Collection and analysis of contamination status survey data on the site
- Detailed investigation of contamination distribution on demonstration site area for carrying out this task of total pollution
Acid sludge reclamation depth is intensively distributed between 2 to 5m underground. According to Pertamina's existing research data, the landfill area is about 7,953㎡ and the volume of contaminated ㎡ soil and acid sludge is 22,561㎥.
- Sampling and pollution level analysis
The analysis results of the heavy metal content and TPH contamination concentration of the acid sludge mass itself are shown in Table 1-3, and as a result of analysis of the block(Plot) TPH(Total Petroleum Hydrocarbons) soil contamination concentration, it was found to be in the range of 0.2 to 9.7%.
- Environmental restoration criteria proposed by Indonesian Ministry of the Environment and survey of standard analysis method data
- Environmental restoration criteria proposed by Indonesian Ministry of the Environment and survey of standard analysis method data
According to the Indonesian Environmental Law (Permen LH no. 33/2009), the site cleanup target level of contamination is determined in the following three ways. 1) setting the purification target according to the background soil concentration, 2) setting the standard purification target according to the use of the site, and 3) setting the purification target based on the risk assessment. For the site, the purification target is set by using the background concentration in the surroundings, and the purification target derived by final agreement by Pertamina, the main body of the Indonesia environmental levitation site purification, is TPH 4,300mg/kg
- Local contaminant distribution characteristics and behavior analysis of contaminant
The landfilled acid sludge is injected along with the toxic gas along the gap of the indicator by the physicochemical action in the ground, it is jetted out in the form of black lava around the site, it is hardened and it seems like past Although it does not become active in the fact, even though the black acid sludge eruption still occurs occasionally even now
B. Applicability study of remediation method for on-site customized remediation
- Confirmation of soil characteristics and background concentration of heavy metals etc. in target area
- Soil contamination level analysis
The TPH concentration by Indonesian standard analysis method was analyzed as 3.2 to 4.2% for soil and 6.8 to 7.4% for acid sludge. In the case of heavy metals, there was no item exceeding the reference value, except for zinc in the Indonesian analysis method, all heavy metals are displayed below the detection limit
- Sorting soil and landfill waste pretreatment experiment
As a result of wet particle size analysis, the fine soil content was about 18.8%, and earthiness was classified as fine granular sand. As a result of observing particles of different particle sizes, solid acid sludge is mixed and distributed in all sectors in various sizes
- Property Analysis of Pulmonary acid Sludge
The calories of Acid sludge itself were about 5,000Kcal/kg, showing calories of low quality coal, and about 11% incombustible content was contained due to the influence of sludge of clay component. As a result of elemental analysis, the content of carbon is 57.8-63.03% and the content of sulfur is less than 4%.
- Applicability test of applicable construction method
As a result of analyzing the characteristics of soil and contaminants, the contaminant acid sludge on the site is waste generated in the wax production process. It is judged to be mainly solid petroleum contaminants, has low bioavailability. And the amount of polluted soil on the entire site is large, it must be cleaned within a short period of time and it must be pursued according to the condition. Therefore, it is considered only for the Ex-situ method of excavation and remediation of contaminated soil, and the applicability test was conducted on the soil remediation method such as soil washing, thermal desorption, bioremediation.
Through this research, as a method of removing TPH most effectively in a short time by applying various TPH removal methods, the thermal desorption method is showed by the most effective construction method
- Derivation of design factors of on-site demonstration plant
The thermal desorption experiment of the target sample was conducted by using conversation based on the result of TGA-DSC. It was judged that it can satisfy the Indonesian environmental standard, which operates the thermal desorption process under the condition of about 350℃~400℃
C. Selection of optimum remediation method and design of demonstration plant(0.5ton/hr)
- Analysis of applicability test results
- On-site applicability and economic consideration of selection method
- Efficiency analysis of refining plant production and on-site installation
- Various permits and regulations and regulatory considerations due to application of remediation method
- Remediation process Examination of treatment method of waste and examination of neighboring waste treatment facility
The only manufacturer that has permission to dispose of waste in Indonesia is PT.
Prasadha Pamunah Limbah Industri(PPLi). Since 1994, PPLi provides harmful / waste collection, disposal, disposal and recycling services. It owns 95% of Modern Asia Environmental Holdings (MAEH) shares. Remaining 5% of MAEH shares are owned by the government of Indonesia
- Economical, efficient, rational, selection of optimum remediation method
Presentation procedure for optimum remediation method selection
- Detailed design of on-site demonstration plant
The direct heat desorption process is separated by soil remediation process and treatment process of air contaminants. In thermal desorption and remediation, contaminated soil separated into 20 mm or less in the screening process is charged into the hopper and discharged to the purified soil after a residence time of about 20 to 30 minutes in the thermal desorption furnace. Oil vapor generated in the kiln. vapor. The fine dust moves to the air contaminant treatment facility of the latter stage according to the negative pressure and is processed
D. Pilot Scale Field demonstration plant (0.5ton/hr) Production and installation, operation
- Pilot plant production and overseas demonstration site transfer plan examination
A South Korean contractor engaged in overseas construction industry (investment,construction, contracting, export of industrial equipment) according to the Article 19 of the Foreign Trade Control Regulations on Article 11 of the Foreign Trade Act and the Enforcement Order 19 of that Act Including the local joint venture corporation), when sending goods necessary for overseas construction work to no-draft, it is necessary to always confirm from the confirmation organization overseas construction association designated by the Minister of Land, Transport and Maritime Affairs
- Review of licensing and detergents of various countries by Transfer overseas plant
- Review of various permits and regulations of the country concerning installation at the plant site and on-site management
With Approval of the state government and approval by the Ministry of the Environment, it is possible to set up a Plant
E. Evaluation of performance and purification efficiency of demonstration plant
- Specification evaluation of on-site demonstration plant => More 0.5ton/hr, 4hr/day
Use a demonstration evaluation device with a capacity of 0.5 tons or more of time.
- Performance evaluation unique to each detailed device of the demonstration plant
- Overall peristalsis test
Explanation of each detailed device of the demonstration plant and the whole interlock test was executed.
- Evaluation of purification efficiency => Purification efficiency with initial contamination concentration ratio of 80% or more And Confirm whether targetconcentration TPH of 1,000mg/kg or less for final purification is achieved
Treating with an initial contaminated soil oil concentration of 54,800mg/kg at a treatment temperature of 400°C. and a residence time of 20minutes, the concentration of oil component in collected soil was analyzed at detection limit or less
F. Optimal process development and economic analysis with consideration of local soil characteristics, pollution characteristics and institution (environmental standards etc.)
- Located near the waterfront, optimal purification process selection considering the geographical location of the site verification site and the characteristics of the tropical climate
Prefectural contaminated grounds were evaluated by carrying out biological, physical washing and thermal desorption tests as sites that can be excavated, and the thermal desorption method was judged by the most appropriate method
- Review of regulation items and emission standards concerning various kinds of wastewater and exhaust gas generated during purification process operation
Regulatory standards concerning air pollution prevention were established for the first time for the entire air quality standard that was unified by using the Decree of the State Minister of Environment No. 2 1988
In connection with emissions standards of five types of fixed pollution sources were established via the Environment Minister's Decree(Decree of the State Minister of Environment No. 13 of 1995)
In relation to harmful gases caused by automobiles, we explain regulations on measurement values of harmful gases and vehicles during idling via Decree of the State Minister of Environment No. 35 of 1993
- Confirm the position of the waste disposal facility in the adjacent area, compare the processing costs
The only manufacturer that has permission to dispose of waste in Indonesia is PT.Prasadha Pamunah LimbahIndustri(PPLi)
MAEH was acquired by Dowa Eco System Co. Ud, a subsidiary of Dowa Holdings Co., Ltd., Japan in 2009, and has implemented solid/liquid waste disposal. It has landfill facilities, waste oil and fluid treatment facilities. Treatment costs are designated waste treatment 200$/ton
- Confirm target of final refining presented by Indonesian Ministry of the Environment (KLH)
KLH and PERTAMINA negotiated, and it was Confirmation as a remediation standard
Based on the law (Permen LH (Minister of Environment Regulation) no. 33/2009, 2009 provision of restoration procedure of land contaminated with hazardous waste> Annex 4, the environmental department and the supplier designate the place of soil reference, analyze more than the minimum number of samples and consult with the reference value of the site restoration based on the law. (TPH 4,300mg/kg)
- Economic seating analysis of refining process through analysis of on-site demonstration operation cost
The purification statement is as follows and the purification unit price per ton of polluted soil was calculated as 188,600 won / ton (157$/ton, exchange rate at the end of 2016), and the unit cost of disposal in the landfill to be compared was 200$/ton
G. Preparation of guidelines for on-site management
- Required licensing items and qualification confirmation for the purification work project on site
It should be declared and approved by Indonesian Ministry of the Environment Regulation 33/2009. And Especially in case of biological treatment Technical requirements are defined by Ministry of the Environment regulation 128/2003
- Survey on the present situation and marketability of Indonesia's soil contamination restoration project
From 2005 to 2008 and 2010 and 2012 , a total of 67 pollution sites were discovered in 12 provinces that volumes of 2,680,601m3, area of 6,930,473m2.
Large-scale contaminated sites with volumes of 2,680,601m3 and 6,930,473m2 in the Riau were discovered, and it is understood that this was caused by the oil and gas industry activity
Currently there is no information on the scale of soil and groundwater pollution officially announced in Indonesia.
When estimated based on the current situation of pollution and purification technology mainly applied, it is predicted that a market of at least about 28 billion won and a maximum of 900billion won will be formed.
- Remediation business of laws and regulations related to progression and various permission and regulation items
- Establish a rational method selection procedure for purification of oil contaminated soil (Oil-polluted soil particularly due to landfill of crude oil refined waste)
Presentation procedure for contamination soil purification method selection
- Arrangement of consideration for field application of the selected purification method
For local application, we must take into consideration the national authorization, emission standards, waste disposal methods, overseas transport compatibility and climate
- Permit and regulation related to excavation of contaminated soil and installation and operation of purification plant
- Organization of safety control items to consider when purifying process operation
In the case of the thermal desorption process, we must pay particular attention to fire, explosion, noise during operation, burn and electric shock during operation, workplace dust
- Contents of remediation process related to generation and treatment of waste
Waste that may occur in the thermal desorption purification process is dust generated during contaminated soil undergoing thermal desorption process in rotary kiln. Dust having large particle size of generated dust is separated by the centrifugal force of the multi cyclone. The dust remaining after the dust collection process passes through the filter cloth of the bag filter. Dust is collected by the principle of trapping dust in this filter cloth. Treatment of dust generated in the thermal desorption process is mixed with purified soil and discharged when the concentration of dust is not more than the reference value of the concern concerning soil contamination. If the concentration of dust is not less than the standard value of concern for soil contamination, dust is treated as designated waste
- Write the final guidelines
Creation of design guidelines and standard operating procedures
( 출처 : SUMMARY 20p )
목차 Contents
- 표지 ... 1
- 제 출 문 ... 3
- 요 약 서 ... 5
- 요 약 문 ... 11
- SUMMARY ... 19
- 목차 ... 29
- 표목차 ... 30
- 그림목차 ... 32
- 1. 연구개발과제의 개요 ... 35
- 1-1. 연구개발 목적 ... 35
- 1-2. 연구개발의 필요성 ... 35
- 1-3. 연구개발 범위 ... 36
- 2. 국내외 기술개발 현황 ... 37
- 2-1. 해외 기술개발 동향 ... 37
- 2-2. 국내 기술개발 동향 ... 37
- 3. 연구수행 내용 및 결과 ... 39
- 3-1. 연구개발의 내용(범위) 및 최종목표 ... 39
- 3-2. 연구개발 결과 및 토의 ... 39
- 3-3. 연구개발 결과 요약 ... 199
- 4. 목표달성도 및 관련분야 기여도 ... 204
- 4-1. 목표달성도 ... 204
- 4-2. 관련분야 기여도 ... 205
- 5. 연구결과의 활용계획 ... 206
- 6. 연구과정에서 수집한 해외과학기술정보 ... 207
- 7. 연구개발결과의 보안등급 ... 208
- 8. 국가과학기술종합정보시스템(NTIS)에 등록한 연구시설·장비 현황 ... 209
- 9. 연구개발과제 수행에 따른 연구실 등의 안전조치 이행실적 ... 210
- 10. 연구개발과제의 대표적 연구실적 ... 211
- 11. 기타사항 ... 212
- 12. 참고문헌 ... 213
- 부 록 ... 219
- 끝페이지 ... 280
※ AI-Helper는 부적절한 답변을 할 수 있습니다.