대기 중 미세입자의 포집 기술 중 여과 집진은 가장 일반적인 공기청정의 방법으로 사용되어진다. 여과 집진에 사용되는 필터는 적용 순간부터 미세 입자가 포집되면서 필터의 내부 구조가 변화된다. 필터의 내부 구조의 변화는 유동장의 변화와 압력손실 변화, 필터의 수명과 효율 특성 변화에 영향을 미치게 된다. 본 연구에서는 필터의 성능과 수명을 향상시키고자 미세입자 대전 조건에 따른 정전필터의 장시간 입자 포집 특성을 알아보았다. KCl 1% 입자를 충돌 분무시켜 발생하여 사용하였고 섬유필터는 멜트블로운 방식으로 제조된 평균직경이 약 3 ㎛인 ...
대기 중 미세입자의 포집 기술 중 여과 집진은 가장 일반적인 공기청정의 방법으로 사용되어진다. 여과 집진에 사용되는 필터는 적용 순간부터 미세 입자가 포집되면서 필터의 내부 구조가 변화된다. 필터의 내부 구조의 변화는 유동장의 변화와 압력손실 변화, 필터의 수명과 효율 특성 변화에 영향을 미치게 된다. 본 연구에서는 필터의 성능과 수명을 향상시키고자 미세입자 대전 조건에 따른 정전필터의 장시간 입자 포집 특성을 알아보았다. KCl 1% 입자를 충돌 분무시켜 발생하여 사용하였고 섬유필터는 멜트블로운 방식으로 제조된 평균직경이 약 3 ㎛인 폴리프로필렌 재질의 정전필터를 사용하였다. 필터의 대전 특성 제거를 위하여 이소프로필 알콜에 침지하여 건조시키는 방법을 사용하여 정전필터의 대전 유 · 무에 대하여 실험하였다. 실험은 농도에 따른 영향, 정전 필터에 따른 영향, 입자 대전에 따른 영향에 대하여 순서대로 진행하였으며 압력손실과 시간, 단위면적당 입자의 양을 측정하고 고찰하였다. 실험결과 미세입자 농도에 대한 영향은 변화율이 유사한 특성을 보였으며, 장시간 입자포집 특성에 영향이 낮은 것을 알 수 있었다. 필터를 대전시킨 정전필터의 경우가 대전특성을 제거한 필터 보다 효율면에서 우수성을 보이고 단위면적당 입자 부하량이 높으며 낮은 공기저항특성을 보이는 것을 확인할 수 있었다. 입자의 대전에 따른 영향은 대전량이 높은 입자일수록 낮은 공기저항 특성이 보임을 확인할 수 있었다. 장시간 포집에 대하여 낮은 공기저항 특성을 보인다는 것은 필터내부의 유동장이 변화하였다는 것을 의미하며 전자현미경을 통해 입자의 포집 형상을 확인 할 수 있었다. 결론적으로 미세입자 대전 조건에 따른 정전필터 장시간 포집시 입자 대전량이 높을수록, 필터의 대전량이 높을수록 낮은 공기저항 특성과 높은 효율특성을 보이므로 필터의 사용수명을 오래 지속 할 수 있으므로 자원낭비의 감소 및 에너지 절약 측면에서 효과적이다.
대기 중 미세입자의 포집 기술 중 여과 집진은 가장 일반적인 공기청정의 방법으로 사용되어진다. 여과 집진에 사용되는 필터는 적용 순간부터 미세 입자가 포집되면서 필터의 내부 구조가 변화된다. 필터의 내부 구조의 변화는 유동장의 변화와 압력손실 변화, 필터의 수명과 효율 특성 변화에 영향을 미치게 된다. 본 연구에서는 필터의 성능과 수명을 향상시키고자 미세입자 대전 조건에 따른 정전필터의 장시간 입자 포집 특성을 알아보았다. KCl 1% 입자를 충돌 분무시켜 발생하여 사용하였고 섬유필터는 멜트블로운 방식으로 제조된 평균직경이 약 3 ㎛인 폴리프로필렌 재질의 정전필터를 사용하였다. 필터의 대전 특성 제거를 위하여 이소프로필 알콜에 침지하여 건조시키는 방법을 사용하여 정전필터의 대전 유 · 무에 대하여 실험하였다. 실험은 농도에 따른 영향, 정전 필터에 따른 영향, 입자 대전에 따른 영향에 대하여 순서대로 진행하였으며 압력손실과 시간, 단위면적당 입자의 양을 측정하고 고찰하였다. 실험결과 미세입자 농도에 대한 영향은 변화율이 유사한 특성을 보였으며, 장시간 입자포집 특성에 영향이 낮은 것을 알 수 있었다. 필터를 대전시킨 정전필터의 경우가 대전특성을 제거한 필터 보다 효율면에서 우수성을 보이고 단위면적당 입자 부하량이 높으며 낮은 공기저항특성을 보이는 것을 확인할 수 있었다. 입자의 대전에 따른 영향은 대전량이 높은 입자일수록 낮은 공기저항 특성이 보임을 확인할 수 있었다. 장시간 포집에 대하여 낮은 공기저항 특성을 보인다는 것은 필터내부의 유동장이 변화하였다는 것을 의미하며 전자현미경을 통해 입자의 포집 형상을 확인 할 수 있었다. 결론적으로 미세입자 대전 조건에 따른 정전필터 장시간 포집시 입자 대전량이 높을수록, 필터의 대전량이 높을수록 낮은 공기저항 특성과 높은 효율특성을 보이므로 필터의 사용수명을 오래 지속 할 수 있으므로 자원낭비의 감소 및 에너지 절약 측면에서 효과적이다.
Amongst several collection technologies of fine particles in the air, filtration collection is used as the most general method for air cleaning. In the filter used for filtration collection, fine particles are collected from the moment that the filter applies and it leads to the change of filter's i...
Amongst several collection technologies of fine particles in the air, filtration collection is used as the most general method for air cleaning. In the filter used for filtration collection, fine particles are collected from the moment that the filter applies and it leads to the change of filter's internal structure. The change in filter's internal structure affects the changes of flow field, pressure drop, filter's life and efficiency property. This study analyzed electret filter's long-time particle loading characteristics depending on the charged conditions of fine particles, in order to improve filter's performance and life. Firstly, 1% of KCl particle was used after impinging spray of it, and an electret filter made with polypropylene which was produced using the melt-blown technology and had an average diameter of nearly 3㎛, was used as a fibrous filter. For removing charged properties of the filter, then, electret filter's charged conditions were experimented, by immersing it in isopropyl alcohol and drying it. The experiment was conducted in order to observe the effects of concentration, electret filter and charged particles and then, pressure drop and time, and the amount of particles were measured and considered. As a result, for the effect of fine particle concentration, the rate of change was within the margin of error. It implies that it didn't have a lot of effect on long-time particle loading characteristics. The charged electret filter had a higher excellence, a lower loading amount of particles per unit area and a lower air resistance than it which removed the charged properties. For the impact of charged particles, the particles with higher charges had a lower air resistance. The low air resistance during long-time loading means that the flow filed inside the filter changed, and particle's collected form was observed by the electron microscope. In conclusion, filter's air resistance is lower and its efficiency is higher, as particle's charge and filter's charge get higher during electret filter's long-time loading, according to the charged conditions of fine articles. In this case, it is possible to lengthen filter's life and thus is effective to reduce waste of resources and conserve energy.
Amongst several collection technologies of fine particles in the air, filtration collection is used as the most general method for air cleaning. In the filter used for filtration collection, fine particles are collected from the moment that the filter applies and it leads to the change of filter's internal structure. The change in filter's internal structure affects the changes of flow field, pressure drop, filter's life and efficiency property. This study analyzed electret filter's long-time particle loading characteristics depending on the charged conditions of fine particles, in order to improve filter's performance and life. Firstly, 1% of KCl particle was used after impinging spray of it, and an electret filter made with polypropylene which was produced using the melt-blown technology and had an average diameter of nearly 3㎛, was used as a fibrous filter. For removing charged properties of the filter, then, electret filter's charged conditions were experimented, by immersing it in isopropyl alcohol and drying it. The experiment was conducted in order to observe the effects of concentration, electret filter and charged particles and then, pressure drop and time, and the amount of particles were measured and considered. As a result, for the effect of fine particle concentration, the rate of change was within the margin of error. It implies that it didn't have a lot of effect on long-time particle loading characteristics. The charged electret filter had a higher excellence, a lower loading amount of particles per unit area and a lower air resistance than it which removed the charged properties. For the impact of charged particles, the particles with higher charges had a lower air resistance. The low air resistance during long-time loading means that the flow filed inside the filter changed, and particle's collected form was observed by the electron microscope. In conclusion, filter's air resistance is lower and its efficiency is higher, as particle's charge and filter's charge get higher during electret filter's long-time loading, according to the charged conditions of fine articles. In this case, it is possible to lengthen filter's life and thus is effective to reduce waste of resources and conserve energy.
※ AI-Helper는 부적절한 답변을 할 수 있습니다.