[논문]Fabrication of self-cleaning fly ash/polytetrafluoroethylene material for cement mortar spray-coating

Chindaprasirt, Prinya; Rattanasak, Ubolluk

doi:10.1016/j.jclepro.2020.121748

Fabrication of self-cleaning fly ash/polytetrafluoroethylene material for cement mortar spray-coating

Journal of cleaner production, v.264, 2020년, pp.121748 -

Chindaprasirt, Prinya (Sustainable Infrastructure Research and Development Center, Department of Civil Engineering, Faculty of Engineering, Khon Kaen University) , Rattanasak, Ubolluk (Department of Chemistry, Faculty of Science, Burapha University)

Abstract ▼ AI-Helper

Abstract Dust pollution has adverse effects on the esthetics and service life of buildings and also increases maintenance costs. The use of a superhydrophobic surface is a promising practice to reduce the accumulation of dust and facilitate the cleaning of surfaces. In addition, a superhydrophobic surface improves the anti-corrosion properties of material, with a reduction in water penetration of concrete. Therefore, this paper presents the fabrication of a self-cleaning fly ash (FA)/polytetrafluoroethylene (PTFE) material for cement mortar spray-coating. To study the self-cleaning properties, the water contact angle and sliding angle of the surfaces were measured. The surface coated with PTFE and 10% FA shows a contact angle of 147°, which indicates a hydrophobic surface, and has self-cleaning properties with a sliding angle of less than 10°. Micro-papillae can be observed on the coated surface and play an important role in preventing water from penetrating the substrate. Ground bagasse ash was used as dust to study the self-cleaning properties. The rolling of a water droplet on the dust-coated surface results in the cleaning of the coated surface, as the dust collects on the droplet surface. The cleaning process can also be achieved with the use of seawater and hydrochloric acid solution droplets. Thus, the FA/PTFE self-cleaning material has the potential to be used for cement mortar coating. Highlights Self-cleaning fly ash/polytetrafluoroethylene material was spray coated on mortar. Fly ash/polytetrafluoroethylene material had potential as self-cleaning material. Rolling of a water droplet on the dusty coated surface had collected the dust. Spray coating is a cost-effective technique to produce superhydrophobic surface. 10% fly ash sample shows a contact angle of 147° and a sliding angle less than 10°. Graphical abstract [DISPLAY OMISSION]

주제어

참고문헌 (27)

Appl. Catal., B Aissa 107 1 2011 10.1016/j.apcatb.2011.06.012 Characterization and photocatalytic performance in air of cementitious materials containing TiO2. Case study of formaldehyde removal

상세보기
Build. Environ. Alfieri 111 72 2017 10.1016/j.buildenv.2016.10.019 Synthesis and characterization of photocatalytic hydrophobic hybrid TiO2-SiO2 coatings for building applications

상세보기
Construct. Build. Mater. Arabzadeh 141 393 2017 10.1016/j.conbuildmat.2017.03.012 Superhydrophobic coatings on Portland cement concrete surfaces

상세보기
Arnold 2003 Comprehensive Structural Integrity Environmentally assisted fatigue
ASTM C618-15 2015 Standard Specification for Coal Fly Ash and Raw or Calcined Natural Pozzolan for Use in Concrete
ASTM D2132-12 2012 Standard Test Method for Dust-And Fog Tracking and Erosion Resistance of Electrical Insulating Materials
Construct. Build. Mater. Chindaprasirt 112 956 2016 10.1016/j.conbuildmat.2016.03.023 Improvement of durability of cement pipe with high calcium fly ash geopolymer covering

상세보기
Mater. Struct. Costa 32 252 1999 10.1007/BF02479594 Chloride penetration into concrete in marine environment-Part I: main parameters affecting chloride penetration

상세보기
Duble 2007 Green Chemistry and Engineering Chapter 5 - alternate solvents
Construct. Build. Mater. Husni 144 385 2017 10.1016/j.conbuildmat.2017.03.078 Superhydrophobic rice husk ash coating on concrete

상세보기
J. Ind. Eng. Chem. Kim 61 39 2018 10.1016/j.jiec.2017.11.045 Engineering lotus leaf-inspired micro- and nanostructures for the manipulation of functional engineering platforms

상세보기
Powder Technol. Liu 193 1 20 2009 10.1016/j.powtec.2009.02.002 Experimental study of acoustic agglomeration of coal-fired fly ash particles at low frequencies

상세보기
J. Clean. Prod. Liu 156 775 2017 10.1016/j.jclepro.2017.03.211 Superhydrophobic and self-cleaning behavior of Portland cement with lotus-leaf-like microstructure

상세보기
Langmuir Miwa 16 5754 2000 10.1021/la991660o Effect of the surface roughness on sliding angles of water droplets on superhydrophobic surfaces

상세보기
Sol. Energy Mater. Sol. Cells Polizos 176 405 2018 10.1016/j.solmat.2017.10.029 Transparent superhydrophobic surfaces using a spray coating process

상세보기
Portland Cement Association vol. 2617 1 2002 Types and Causes of Concrete Deterioration
Sci. Rep. Quan 6 38239 2016 10.1038/srep38239 Self-cleaning of surfaces: the role of surface wettability and dust types

상세보기
Mater. Lett. Shah 203 17 2017 10.1016/j.matlet.2017.05.126 A durable superhydrophobic coating for the protection of wood materials

상세보기
J. Clean. Prod. Shen 87 762 2015 10.1016/j.jclepro.2014.10.014 Preparation of titanium dioxide nano particle modified photocatalytic self-cleaning concrete

상세보기
Rep. Prog. Phys. Simpson 78 14pp 2015 10.1088/0034-4885/78/8/086501 Superhydrophobic materials and coatings: a review

상세보기
J. Coating Technol. Res. Su 9 2 135 2012 10.1007/s11998-009-9230-0 A simple and cost-effective method for fabricating lotus-effect composite coatings

상세보기
Colloids Surf., A Wang 513 389 2017 10.1016/j.colsurfa.2016.11.001 Fabrication of artificial super-hydrophobic lotus-leaf-like bamboo surfaces through soft lithography

상세보기
J. Colloid Interface Sci. Wang 402 253 2013 10.1016/j.jcis.2012.11.011 The fabrication, nano/micro-structure, heat- and wear-resistance of Superhydrophobic PPS/PTFE composite coatings

상세보기
Cement Concr. Res. Wong 70 9 2015 10.1016/j.cemconres.2015.01.005 Hydrophobic concrete using waste paper sludge ash

상세보기
World Health Organization 1998 Environmental Criteria 207: Acetone. Geneva
Appl. Surf. Sci. Zhang 284 319 2013 10.1016/j.apsusc.2013.07.100 Self-cleaning superhydrophobic surface based o titanium dioxide nanowires combined with polydimethylsiloxane

상세보기
Environ. Sci. Technol. Zhang 53 1913 2019 In-situ capture of mercury in coal-fired power plants using high surface energy fly ash

내보내기 구분	파일저장 인쇄 메일전송
구성항목	기본정보 상세정보 관리번호, 논문명, 저널/프로시딩명, 저자 , 발행년, 권, 호, 시작페이지, 끝페이지, 발행기관 관리번호, 논문명, 대등논문명, 저자 , 저널/프로시딩명, 발행기관, 발행년, 발행언어, 권, 호, 시작페이지, 끝페이지, ISBN, ISSN, 주제분야, 키워드, 초록(한글), 초록(영문), 저자(소속기관)
저장형식	Text(ASCII format) Excel format RefWorks Direct Export RIS format (for Reference Manager, ProCite, EndNote), Scholar's Aids, Mendeley
메일정보	받는사람 (필수) @ 보내는사람 (선택) @ 제목 내용 KISTI 검색결과 이메일 서비스
안내	총 건의 자료가 검색되었습니다. 다운받으실 자료의 인덱스를 입력하세요. (1-10,000) 검색결과의 순서대로 최대 10,000건 까지 다운로드가 가능합니다. 데이타가 많을 경우 속도가 느려질 수 있습니다.(최대 2~3분 소요) 다운로드 파일은 UTF-8 형태로 저장됩니다. 파일의 내용이 제대로 보이지 않을실 때는 웹브라우저 상단의 보기 -> 인코딩 -> 자동선택 여부를 확인하십시오. ~ Text(ASCII format) Excel format

연합인증

Fabrication of self-cleaning fly ash/polytetrafluoroethylene material for cement mortar spray-coating

Abstract ▼ AI-Helper

주제어

참고문헌 (27)

이 논문을 인용한 문헌

관련 콘텐츠

원문 URL 링크

이 논문과 함께 이용한 콘텐츠

AI-Helper ※ AI-Helper는 오픈소스 모델을 사용합니다.

선택된 텍스트