[논문]Sommerfeld effect at forward and backward critical speeds in a rigid rotor shaft system with anisotropic supports

Bharti, Saurabh Kumar; Bisoi, Alfa; Sinha, Anubhab; Samantaray, A.K.; Bhattacharyya, R.

doi:10.1016/j.jsv.2018.11.002

Sommerfeld effect at forward and backward critical speeds in a rigid rotor shaft system with anisotropic supports

Journal of sound and vibration, v.442, 2019년, pp.330 - 349

Bharti, Saurabh Kumar (Corresponding author.) , Bisoi, Alfa , Sinha, Anubhab , Samantaray, A.K. , Bhattacharyya, R.

Abstract ▼ AI-Helper

Abstract A rotor dynamic system requires high power/torque to accelerate through its resonance conditions or critical speeds to operate at a super-critical speed. Most practical drive sources are non-ideal in nature, i.e. they can only provide a limited amount of power to the rotor system. Thus, if there is insufficient power to overcome a resonance then the rotor speed may get arrested at that resonance or take a long time to escape from the resonance; and thereby damage the system. For the present analysis, a Direct Current (DC) motor is considered as the non-ideal prime mover for a rigid rotor shaft with unbalanced disk which is supported by flexible anisotropic supports/bearings. Due to the anisotropy in the supports, both forward and backward whirl motions of the rotor get excited. This causes a multi-Sommerfeld effect where two non-linear jump phenomena are manifested at the first forward and backward critical speeds during rotor coast up and coast down. When the two critical speeds are close to each other, a complex speed capture and jump phenomena occurs. Accordingly, the transitions through both resonance conditions are examined. At first, the analytical solutions are obtained under steady state assumption and then transient simulations are performed with the help of a bond graph (BG) model. Highlights Sommerfeld effect at forward and backward critical speeds in a rotor is studied. Steady-state analysis is performed with input-output averaged energy balance. Interference of two Sommerfeld effects at close critical speeds is observed. Simulations are performed to find critical power input to escape double resonance.

주제어

참고문헌 (53)

J. Eng. Ind. Trans. ASME Lund 89 785 1967 10.1115/1.3610155 Calculations and experiments on the unbalance response of a flexible rotor

상세보기
J. Eng. Ind. Trans. ASME Kirk 94 221 1972 10.1115/1.3428115 The effect of support flexibility and damping on the synchronous response of a single-mass flexible rotor

상세보기
J. Eng. Power, Trans. ASME Barrett 100 89 1978 10.1115/1.3446331 Optimum bearing and support damping for unbalance response and stability of rotating machinery

상세보기
Gunter 1966 Dynamic Stability of Rotor-bearing Systems, NASA SP-113
Vance 1988 Rotordynamics of Turbomachinery
Genta 2005 Dynamics of Rotating Systems
J. Sound Vib. Muszynska 192 1 207 1996 10.1006/jsvi.1996.0184 Forward and backward precession of a vertical anisotropically supported rotor

상세보기
Greenhill vol. 3 1995 Cornejo.: critical speeds resulting from unbalance excitation of backward whirl modes
J. Eng. Gas Turbines Power, Trans. ASME Vazquez 124 2002 Flexible bearing supports, using experimental data
J. Eng. Ind., Trans. ASME, Series B Gunter 89 4 683 1967 10.1115/1.3610135 The influence of internal friction on the stability of high speed rotors

상세보기
Tondl 1965 Some Problems of Rotor Dynamics
Dimentberg 1961 Flexural Vibrations of Rotating Shafts
J. Appl. Mech. Lund 32 4 911 1965 10.1115/1.3627335 The stability of an elastic rotor in journal bearings with flexible, damped supports

상세보기
Nonlinear Dynam. Dimentberg 13 171 1996 10.1023/A:1008205012232 Dynamics of an unbalanced shaft interacting with a limited power supply
Int. J. Eng. Sci. Samantaray 48 1 21 2010 10.1016/j.ijengsci.2009.06.005 Sommerfeld effect in rotationally symmetric planar dynamical systems

상세보기
Tech. Mech. Ryzhik 21 4 297 2001 Zum Sommerfeld effect beim selbsttatigen Auswuchten in einer Ebene
Nonlinear Dynam. Quinn 57 4 623 2009 10.1007/s11071-009-9502-3 Resonant dynamics in a rotordynamic system with nonlinear inertial coupling and shaft anisotropy

상세보기
Blekhman 2000 Vibrational Mechanics: Nonlinear Dynamic Effects. General Approach, Applications
Eng. Trans. Bleckman 16 1953 Self-Synchronization of certain vibratory devices
Evan-Iwanowski 1976 Resonance Oscillators in Mechanical Systems
Dimentberg 1988 Statistical Dynamics of Nonlinear and Time Varying Systems
Phys. Z. Sommerfeld 3 266 1902 Beitrage Zum Dynamischen Ausbau der Festigkeitslehe
Nayfeh 1979 Nonlinear Oscillations
Kononenko 1964 Vibrating Systems with Limited Excitation [in Russian]
Balthazar vol. 1 97 1997 Some observations on numerical simulations of a non-ideal dynamical system
Weber 137 1999 49th Brazilian Seminar of Mathematical Analysis On vibrating systems with a limited power supply and their applications to engineering sciences
Balthazar 27 2001 Sixth Conference on Dynamical Systems Theory and Applications, Lodz, Poland Recent results on vibrating problems with limited power supply
Meccanica Balthazar 330 7 1 2002 Recent results on vibrating problems with limited power supply
Appl. Mech. Mater. Balthazar 1 2 51 2004 10.4028/www.scientific.net/AMM.1-2.51 On non-ideal simple Portal Frame structural model: experimental results under a non-ideal excitation

상세보기
J. Sound Vib. Goncalves 333 20 5115 2014 10.1016/j.jsv.2014.05.039 The dynamic behavior of a cantilever beam coupled to a non-ideal unbalanced motor through numerical and experimental analysis

상세보기
J. Sound Vib. Blekhman 405 306 2017 10.1016/j.jsv.2017.05.045 Vibrational resistance to vehicle motion due to road unevenness

상세보기
Alifov 1990 Interaction of Non-linear Oscillatory Systems with Energy Sources
Meccanica Balthazar 38 613 2003 10.1023/A:1025877308510 An overview on non-ideal vibrations
J. Sound Vib. Bhattacharyya 264 973 2004 10.1016/S0022-460X(02)01540-7 Harmonic oscillations of non-conservative, asymmetric, two-degree-of-freedom systems

상세보기
Nonlinear Dynam. Samantaray 56 4 443 2009 10.1007/s11071-008-9413-8 Steady-state dynamics of a non-ideal rotor with internal damping and gyroscopic effects

상세보기
J. Sound Vib. Bisoi 411 304 2017 10.1016/j.jsv.2017.09.014 Control strategies for DC motors driving rotor dynamic systems through resonance

상세보기
Meccanica Bisoi 53 4-5 681 2018 10.1007/s11012-017-0757-3 Sommerfeld effect in a two-disk rotor dynamic system at various unbalance conditions

상세보기
J. Sound Vib. Kong 427 63 2018 10.1016/j.jsv.2018.04.002 Composite synchronization of a four eccentric rotors driven vibration system with a mass-spring rigid base

상세보기
Nonlinear Dynam. Sinha 93 1719 2018 10.1007/s11071-018-4287-x Sommerfeld effect in an oscillator with a reciprocating mass

상세보기
J. Braz. Soc. Mech. Sci. Eng. Lima 38 931 2016 10.1007/s40430-015-0395-4 Two parametric excited nonlinear systems due to electromechanical coupling

상세보기
Int. J. Nonlinear Mech. Samantaray 43 9 1012 2008 10.1016/j.ijnonlinmec.2008.06.011 A note on internal damping induced self-excited vibration in a rotor by considering source loading of a DC motor drive

상세보기
Int. J. Non Lin. Mech. Cveticanin 94 125 2017 10.1016/j.ijnonlinmec.2017.03.002 Two degree-of-freedom oscillator coupled to a non-ideal source

상세보기
Mech. Mach. Theor. Karthikeyan 91 269 2015 10.1016/j.mechmachtheory.2015.04.016 Sommerfeld effect characterisation in rotors with non-ideal drive from ideal drive response and power balance

상세보기
Bisoi vol.88 1565 2018
Karnopp 2006 System Dynamics: Modelling and Simulation of Mechatronic Systems
Borutzky 2010 Bond Graph Methodology Development and Analysis of Multidisciplinary Dynamic System Models
J. Sound Vib. Mishra 377 302 2016 10.1016/j.jsv.2016.05.021 Bond graph modeling and experimental verification of a novel scheme for fault diagnosis of rolling element bearings in special operating conditions

상세보기
J. Sound Vib. Mishra 400 86 2017 10.1016/j.jsv.2017.04.010 Ball bearing defect models: a study of simulated and experimental fault signatures

상세보기
J. Sound Vib. Jain 413 159 2018 10.1016/j.jsv.2017.10.027 A novel approach to study effects of asymmetric stiffness on parametric instabilities of multi-rotor-system

상세보기
Merzouki 2012 Intelligent Mechatronic Systems: Modeling, Control and Diagnosis
Mukherjee 2012 Bond Graph in Modeling, Simulation and Fault Identification
Int. J. Non-linear Mech. Dasgupta 45 3 286 2010 10.1016/j.ijnonlinmec.2009.12.002 Stability of an internally damped non-ideal flexible spinning shaft

상세보기
Mukherjee 2006 SYMBOLS-shakti User’s Manual

내보내기 구분	파일저장 인쇄 메일전송
구성항목	기본정보 상세정보 관리번호, 논문명, 저널/프로시딩명, 저자 , 발행년, 권, 호, 시작페이지, 끝페이지, 발행기관 관리번호, 논문명, 대등논문명, 저자 , 저널/프로시딩명, 발행기관, 발행년, 발행언어, 권, 호, 시작페이지, 끝페이지, ISBN, ISSN, 주제분야, 키워드, 초록(한글), 초록(영문), 저자(소속기관)
저장형식	Text(ASCII format) Excel format RefWorks Direct Export RIS format (for Reference Manager, ProCite, EndNote), Scholar's Aids, Mendeley
메일정보	받는사람 (필수) @ 보내는사람 (선택) @ 제목 내용 KISTI 검색결과 이메일 서비스
안내	총 건의 자료가 검색되었습니다. 다운받으실 자료의 인덱스를 입력하세요. (1-10,000) 검색결과의 순서대로 최대 10,000건 까지 다운로드가 가능합니다. 데이타가 많을 경우 속도가 느려질 수 있습니다.(최대 2~3분 소요) 다운로드 파일은 UTF-8 형태로 저장됩니다. 파일의 내용이 제대로 보이지 않을실 때는 웹브라우저 상단의 보기 -> 인코딩 -> 자동선택 여부를 확인하십시오. ~ Text(ASCII format) Excel format

연합인증

Sommerfeld effect at forward and backward critical speeds in a rigid rotor shaft system with anisotropic supports

Abstract ▼ AI-Helper

주제어

참고문헌 (53)

이 논문을 인용한 문헌

관련 콘텐츠

원문 URL 링크

이 논문과 함께 이용한 콘텐츠

AI-Helper ※ AI-Helper는 오픈소스 모델을 사용합니다.

선택된 텍스트